LIAO Ma-HuaYAN Wen-YanCAI XiangZHANG Xiu-JuLIN Zhi-DanTAN Shao-Zao＊,

(1Department of Chemistry,Jinan University,Guangzhou 510632,China)

(2College of Science and Engineering,Jinan University,Guangzhou 510632,China)

Thermal Stability and Antibacterial Activity of Phosphonium Salts Pillared Layered α-Zirconium Phosphates

LIAO Ma-Hua1YAN Wen-Yan1CAI Xiang1ZHANG Xiu-Ju2LIN Zhi-Dan2TAN Shao-Zao＊,1

(1Department of Chemistry,Jinan University,Guangzhou 510632,China)

(2College of Science and Engineering,Jinan University,Guangzhou510632,China)

Dodecyl tributyl phosphonium bromide pillared layered α-zirconium phosphate (DDTB-ZrPs)was prepared by introducing dodecyl tributyl phosphonium bromide(DDTB)into layered α-zirconium phosphate(ZrP) through ion-exchange method,and the resulting DDTB-ZrPs were characterized by FTIR,XRD,TEM,and TGA/ DTG techniques.Minimum inhibitory concentration (MIC)was used to evaluate antibacterial activity.The results show that the DDTB are intercalated into ZrP and the basal spacing of DDTB-ZrP is enlarged with the increase in phosphonium salt content.DDTB-ZrP-1 with 5.61wt%of DDTB,shows the highest temperature resistant,the 5% weight loss temperature could be up to 320℃ and the max decomposition rate temperature reaches to 384℃. DDTB-ZrP-6 with 26.46wt%of DDTB displays the highest antibacterial activity for the MIC against E.coli and S. aureus of 80 and 15 mg·L-1,respectively.Further analyses indicate that along with the increase in the content of DDTB,the thermostability of DDTB-ZrPs decreases and the antibacterial activity improves.

α-zirconium phosphate;dodecyl tributyl phosphonium bromide;thermal stability;antibacterial activity

In recent years, silver-based inorganic antibacterial materialshavebeen studied asthe preferred antimicrobials because of the advantages of broad-spectrum,long-term resistant,excellent heatresistant and high safety[1-3].Nevertheless,applications of inorganic antibacterial agents are limited because ofthe high cost,easy discolor and poor mouldproof effects.So,researchers have turned their attention to the substitutes. Compare to inorganic antibacterial materials,organic antibacterial pillared clay minerals have attracted substantial attention both in fundamental research and industrial applications due to their superior antibacterial activity,good water resistance, high safety and the synergistic effect with other antimicrobial agents[4].The main shortcomings of clay minerals are poor purity,large particle size with wide distribution,difficult for cleaning due to high viscosity.Therefore,it is necessary to seek for new intercalation materials without the shortcomings.

Zirconium bis-(monohydrogen orthophosphate) monohydrate (Zr(HPO4)2·H2O),also called layered αzirconium phosphate (ZrP),are drawing increasing attention because of its ability to serve as catalysts, solid electrolytes,and molecular sieves[5-7].ZrP can also be used as host material to intercalate guest species, such as alkylamines,diamines and poly-amines, alkanols,glycols,urea and its derivatives,hydrazine, piperidine,dimethyl sulfoxide,dimethyl formamide, heterocyclic bases(imidazole,benzimidazole,alcohols and histamine),metal complexes,porphyrins,amino azobenzene[8-15].Organic antibacterial material exchanged into ZrP may give novel antibacterial material with excellent antibacterial activity and high temperature resistance.

The main goal of this study is to develop a novel α-ZrP based antibacterial material with high temperature resistance and good antibacterial activity.Here we report an antibacterial material obtained by intercalation of quaternary phosphonium cation into ZrP and the discussion on main factors affecting the tempera ture resistance and antibacterial activity.

1 Experimental

1.1 Materials

Zirconium oxychloride octahydrate(ZrOCl2·8H2O, 98%)and phosphoric acid (H3PO4,volume fraction 85%)were obtained from Fisher Scientific.Dodecyl tributyl phosphonium bromide of C.P.grade was supplied byQingteChemicalIndustry Co.,Ltd. (Shanghai,China).Escherichia coli (E.coli)ATCC 25922 and Staphylococci aureus (S.aureus)ATCC 6538 were supplied by Guangdong Institute of Microbiology (Guangzhou,China).Mueller-Hinton broth and nutrient agar culture medium were from Huankai Microorganism Co,Ltd.(Guangzhou,China).All other chemicals were commercial available ones in reagent grade.

1.2 Preparation of DDTB pillared ZrP

ZrP was prepared by hydrothermal method.ZrP was used before intercalation with methylamine[16].Dodecyl tributyl phosphonium bromide(DDTB)pillared ZrP was prepared by the following procedure:α-ZrP was suspended in aqueous solutions of DDTBPBr at various DDTBP+/ZrP molar ratios(0.1∶1,0.25∶1,0.5∶1,1∶1,2∶1 and 5∶1)with constant stirring at 60℃ for 6 h producingDDTBP-intercalated ZrP materialswith different loading levels.For example,the 1∶1 DDTBP-exchanged ZrP material was prepared by suspending 0.1mol of α-ZrP in 500 mL of a 0.1 mol DDTBPBr aqueous solution.The mixture was filtered,and the solid was washed with distilled water water until free from Clion as tested with 1%AgNO3solution.After dried at 60℃under vacuum for 2 d,This layered compound is white odorless and easy flow of powder,300 mesh sieve rate of≥90%.The resulting pillared layered compounds were designated as DDTB-ZrP-1,DDTBZrP-2,DDTB-ZrP-3,DDTB-ZrP-4,DDTB-ZrP-5 and DDTB-ZrP-6,respectively.

1.3 Characterization

Fourier transform infrared spectra (FTIR)were recorded with the Perkin-Elmer-Spectrum GXSpectrophotometer using KBr pellet.X-ray diffraction (XRD)patterns of the DDTB-ZrPs were obtained using a Siemens D5000 powder diffractometer employing Cu Kα radiation(λ=0.154 18 nm)with a filtered flat LiF secondary beam monochromator.The X-ray tube was operated at 45 kV and 40 mA.All XRD patterns were collected with 2θ range of 2.0°～40°at a scanning rate of 1°·min-1.Thermogravimetric analysis (TGA)was conducted with a thermal analyzer(NETZSCH TG 209) under N2flow,in a temperature range of 40～900℃and the scanning rate of 10℃·min-1.Transmission Electron Microscopy(TEM)images were obtained with CM300 with an accelerating voltage of 200 kV.

1.4 Antibacterial activity assay

The minimum inhibitory concentration (MIC)of DDTB-ZrPs against E.coli and S.aureus was measured by two-fold diluting method[17].Briefly,DDTB-ZrPs were suspended into Mueller-Hinton broth medium to form homogeneous suspensions and then two-fold diluted into different concentrations.Each 1 mL of culture medium containingvariousconcentrationsoftest sample was inoculated with 0.1 mL of 106 cfu·mL-1(Colony Forming Units·mL-1)bacterial suspension, cultured for 24 h at 37℃under shaking,and then the growth of bacteria was observed.When no growth of bacteria was observed in the lowest concentration of test sample,the MIC of the sample was defined as this value of dilution,the test for every MIC of DDTB-ZrPs was repeated three times.

1.5 Desorption test

Desorption of phosphonium salts from DDTB-ZrPs was carried out by the process that 0.1 g sample was soaked in 20 mL deionized water in a polypropylene bottle at 40℃on incubator shaker.As the experimental time was 6,12,24,48,60 and 72 h,the released quantity of DDTB from DDTB-ZrPs was measured by thermogravimetric analysis,and the MIC of soaked DDTB-ZrP against E.coli and S.aureus was also tested.

2 Results and discussion

2.1 Structure analysis

The FTIR spectra of ZrP and DDTB-ZrPs(Fig.1) show that the bands at 3 595,3 510 and 3 155 cm-1are due to-OH stretching mode of P-OH of ZrP structure.The bands at 1 250 and 595 cm-1are caused by stretching vibration of in-plane deformation vibration of P-OH.The strong bands near 1 051 and 966 cm-1are probably caused by stretching vibration of P-O,The peaks at 2 931 and 2 857 cm-1are ascribed to the asymmetric and symmetric vibration of methylene groups(CH2)nof the aliphatic chain[18-19].

Fig.1 FTIR spectra of a-ZrP and DDTB-ZrPs

Fig.2 XRD patterns of ZrP and DDTB-ZrPs

Fig.2 shows the XRD patterns of ZrP and DDTBZrPs.The corresponding basal spacing(d002)is shown in Table 1,and results are summarized as follows:(1)XRD pattern of ZrP(d-spacings of 0.76,0.44,0.35 and 0.26 nm),all the above data agree with literature values[20-22]and displays structure similar to clays.The diffraction peak at 2θ=11.9°is assigned to the basal spacing(d002) of 0.76 nm.The XRD patterns show the formation of a new phase with an expanded basal spacing of 1.28～2.58 nm which is much larger than that(d002=0.76 nm)of ZrP,and is attributed to the pillar of DDTB in the interlayer of ZrP.The basal spacing of DDTB-ZrPs is enlarged with the increasing of DDTB contents.

The thermogravimetric (TGA)curves of ZrP and DDTB-ZrPs are shown in Fig.3.According to the weightloss in the TG curves,the decomposition of ZrP clearly occurred in two general regions below 900℃:(1) evaporation of free (absorbed)and interlayer water comprising the hydration spheres of the cations between 50～200℃, (2)dehydroxylation of the ZrP lattice between 500～700℃.In contrast,the TGA curves of DDTB-ZrPs may be conveniently divided into three regions[23]:(1)desorption of absorbed water and gases below 200 ℃ , (2)decomposition of the organic substances between 200～500℃,(3)dehydroxylation of the ZrP lattice between 500～700℃.So,the DDTB contents of DDTB-ZrPs could be determined in range (2)(200～500℃),and the DDTB contents of DDTBZrPs are given in Table 1.

Table 1 Structure and property parameters for ZrP and DDTB-ZrPs

In this work,5%weight loss temperature of DDTB is taken as an indicator of thermal stability of DDTB[24], according to TGA curves, significant thermal degradation temperature of DDTB-ZrPs is given in Table 1.And the temperatures of max decomposition rate of DDTB-ZrPs are also given in Table 1.

Fig.3 TGA curves of a-ZrP and DDTB-ZrPs

So,the TG results indicate that with the increasing of the DDTB content,the 5%weight loss temperature and the max decomposition temperatures of the DDTBZrPs decrease.

TEM analysis (Fig.4)indicates that the crystal

Fig.4 TEM images of of α-ZrP and DDTB-ZrPs

layer of the DDTB-ZrPs was agglomerated than that of ZrP.With the increasing of the DDTB content,the crystal layer of the DDTB-ZrPs is agglomerated more.

Zeta potential and average particle size of ZrP and DDTB-ZrPs(Table 1)show that:(1)with the increasing of the DDTB content,the ζ potential of the DDTB-ZrPs is more positively charged,(2)with the increasing of the DDTB content,the particle size of the DDTB-ZrPs becomes larger.

2.2 Antibacterial activity

The antibacterial activity of ZrP and DDTB-ZrPs against E.coli and S.aureus is shown in Table 2.ZrP shows poor antibacterial activity (both of the MIC values are higher than 20 000 mg·L-1).However, DDTB-ZrPs show relatively high antibacterial activity against E.coli and S.aureus,and the antibacterial activity enhances with the increasing of the phosphonium salt content.

Table 2 Antibacterial activity of DDTB-ZrPs

The IR and XRD results evidence the successful preparation of ZrP and formation of the pillared DDTBZrPs by DDTB intercalation between layers of ZrP,On the basis of the measured basal spacing and the length of the alkyl chains,various models have been proposed for the intercalated surfactants,including lateral-monolayer(LM),lateral-bilayer(LB),pseudotrilayer(PT),paraffin-monolayer(PM)and paraffinbilayer(PB)[25-26].According to the data of van der Waals radius,covalent bond radius and bond angle,the steric configuration,size and shape of organic molecules or cations could be calculated[27].In our study,the layer thickness of ZrP is 0.76 nm,with the increase of DDTB concentration,five typical basal spacings are obtained: (1)～1.28 nm,(2)～1.32 nm,(3)～2.42 nm,(4)～2.52 nm, (5)～2.58 nm,corresponding to the arrangement models oflateral-monolayer (DDTB-ZrP-1,DDTB-ZrP-2, DDTB-ZrP-3),lateral-monolayer add parafn-monolayer (DDTB-ZrP-4,DDTB-ZrP-5,DDTB-ZrP-6),respectively.Simultaneously,the obviously transformation of thearrangementmodelsofDDTB representthe products of the intermediate stage in the course of preparation of DDTB intercalated ZrP[26,28-29].

The TG and DTG curves of the DDTB are represented in Fig.5.The 5%weight loss temperature of DDTB is 210℃,and the max decomposition rate temperature is 248℃.

Fig.5 TG and DTG curves of the DDTB

On the other hand,the 5% weightloss temperatures of DDTB-ZrPs are all higher than 256℃, and the max decomposition rate temperature are all higher than 302℃.Which means DDTB pillared ZrP exhibits excellent thermal stability, can bear temperatures of nanocomposites processing during 200～300℃.What is more,the ZrP with low-concentration DDTB exhibits better thermal stability,this may be that with the increasing in the content of DDTB in ZrP, DDTB becomes more susceptible to heat.

TEM (Fig.4),ζ potential and average particle size (Table 1)follows the same rule:with the increase of the DDTB content,the particle of the DDTB-ZrPs is agglomerated even more.This is due to negatively charged ZrP and positively charged DDTB.Following DDTB insertion into ZrP,the potential value of DDTBZrP gradually declines and the repelling force between particles gradually diminishes, thus more agglomeration.

DDTB-ZrPs show relatively high antibacterial activity against E.coli and S.aureus,and the antibacterial activity is enhanced with the increase in the phosphonium salt content.On the other hand,with the increase in the phosphonium salt content,the thermo tolerance of DDTB-ZrPs decreases.This means that the antibacterial activity and the thermo tolerance is a pair of incompatible system.And for industrial applications,one must find a balance point between the antibacterial activity and the thermo tolerance.In addition,DDTB-ZrPs exhibits lower activity against E. coli than against S.aureus.The structure of the cell wall of E.coli is more complicated than that of the S.aureus because another layer outside of the peptidoglycan layer is called outer membrane,which is composed mainly of lipopolysaccharides and phospholipids. Outer membrane plays a significant role to protect bacteria cells from foreign compounds such as DDTB-ZrP.Thus, the lower sensitivity of DDTB-ZrPs towards E.coli is mainly due to the presence of the outer membrane[30].

The stability of intercalated ZrP in water is evaluated,and the water resistance test of DDTB-ZrP-4 is given in table 3.During the first 48 h,DDTB is released quickly with the soaking time,and then released slowly.The released quantity of DDTB from DDTB-ZrP-4 is only 2.72%(mass fraction)until 72 h, testing for antibacterial activity of soaked DDTB-ZrP-4 (0.9%,mass fraction,40℃)is intended to study the effects of soaking time on the antibacterial activity of DDTB-ZrP,and the result is shown in Table 3.The MIC of DDTB-ZrP-4 against E.coli and S.aureus shows good antibacterial activity all the experimental time.And the MIC value is 300 mg·L-1and 180 mg· L-1MIC against E.coli and S.aureus until 72 h, respectively.

Table 3 Long-acting antibacterial activity of DDTB-ZrP1.0

3 Conclusions

A high temperature resistant and predominant antibacterial material: DDTB pillared ZrP was developed,and the effects of microstructure on the thermal stability and antibacterial activity were studied. Comparing with DDTB,the thermostability of DDTB inserted ZrP is improved significantly, (2)with the increase in content of DDTB inserted into α-ZrP,the arrangement of DDTB changes from lateral-monolayer arrangement to paraffin-type monolayer arrangement, the potential value of DDTB-ZrPs gradually declines and the repelling force between particles gradually diminishes,the partical size of DDTB-ZrPs becomes larger and the antibacterial activity of DDTPB-ZrPs becomes better,but the thermal stability of DDTB-ZrPs becomes worse,(3)the antibacterial activity and the thermo tolerance ofDDTB-ZrPs is a pair of incompatible system:along with the increase in the content of DDTB,the thermo tolerance of DDTB-ZrPs decreases,but the antibacterial activity improves.

Acknowledgements:This work was supported by the National Natural Science Foundation of P.R.China(No. 20676049,20871058 and 20971028),the Foundation of Enterprise-University-Research Institute Cooperation from Guangdong Province and the Ministry of Education of China (Grant No.2007B090400105 and 2008A010500005),and the Term Projects of Scientific Cultivation and Innovation Fund from Jinan University.

[1]TAN Shao-Zao(譚紹早),DING Liu-Cai(丁劉才),LIU Ying-Liang(劉應亮),et al.Chinese Chem.Lett.(Zhongguo Huaxue Kuaibao),2007,18(1):85-88

[2]Zhang L Z,Yu J C,Yip H Y,et al.Langmuir.,2003,19:10372-10380

[3]Tan S Z,Zhang L L,Huang L H,et al.J.Ceram.Soc.Jpn., 2007,115:269-271

[4]NI Jia-Za(倪嘉纘).Rare-earth Bioinorganic Chemistry(稀土生物無機化學).Beijing:Science Press,2002.

[5]Clearfield A,Tindwa R M.J.Inorg.Nucl.Chem.,1979,41: 871-873

[6]Karlsson M,Andersson C,Hjortkjaer J.J.Mol.Catal.A-Chem., 2001,166:337-339

[7]Bermúdez R A,Colón Y,Tejada G A.Langmuir,2005,21:890-894

[8]Bellezza F,Cipiciani A,Costantino U.Langmuir,2002,18: 8737-8742

[9]Hoppe R,Alberti G,Costantino U,et al.Langmuir,1997,13: 7252-7257

[10]Marta B V,Simon J K,Gary B H.Chem.Mater.,2002,14: 2656-2663

[11]Kijima T,Machida S M.Inorg.Chem.,1994,33:2586-2591

[12]Costantino U,Vivani R,Zima V.et al.Langmuir,2002,18: 1211-1217

[13]Bellezza F,Cipiciani A,Costantino U.Langmuir,2004,20: 5019-5025

[14]Vermeulen L A,Thompson M E.Nature,1992,358:656-658

[15]Challa V,Kumar A C.J.Am.Chem.Soc.,2000,122:830-837

[16]Sun L,Boo W J,Sue H J,et al.Chem.Mater.,2007,19:1749-1754

[17]Kasuga N C,Sekino K,Koumo C,et al.J.Inorg.Biochem., 2001,84:55-65

[18]Errera P,Burghardt R C,Phillips T D.Vet.Microbiol., 2000,74:259-272

[19]Atel H A,Somani R S,Bajaj H C,et al.Appl.Clay Sci., 2007,35:194-200

[20]Clearfield A,Duax W L,Medina A S,et al.J.Phys.Chem., 1969,73:3424-3430

[21]Kijima T,Watanabe S,Machida M.Inorg.Chem.,1994,33: 2586-2591

[22]Xu J,Li R K Y,Xu Y,et al.Eur.Polym.J.,2005,41:881-885

[23]Xie W,Gao Z M,Pan W P,et al.Chem.Mater.,2001,13: 2927-2932

[24]CAI Xiang(蔡祥),TAN Shao-Zao(譚紹早),LIAO Ma-Hua (廖馬花),et al.J.Cent.South Univ.Technol.(Zhongnan Daxue Xuebao),2010,17:485-491

[25]Vaia R A,Teukolsky R K,Giannelis E P.Chem.Mater., 1994,6:1017-1022

[26]ZHU Jian-Xi(朱建喜),HE Hong-Ping(何宏平),GOU Jiu-Gao (郭九皋),et al.Chinese Sci.Bull.(Kexue Tongbao),2003,48: 368-372

[27]ZHOU Gong-Du(周公度).Inorganic Structural Chemistry (無機結構化學).Beijing:Science Press,1984.

[28]Tamura K,Nakazawa H.Clay Miner.,1996,44:501-505

[29]He H P,Yang D,Yuan P,et al.J.Colloid Interf.Sci.,2006, 297:235-243

[30]Yoon K Y,Byeon J H,Park C W,et al.J.Environ.Sci. Technol.,2008,42:1251-1255

季鏻陽離子柱撐磷酸鋯的熱穩定性及抗菌活性

廖馬花1顏文艷1蔡 祥1張秀菊2林志丹2譚紹早＊,1

(1暨南大學化學系，廣州 510632)
(2暨南大學理工學院，廣州 510632)

采用離子交換法將不同含量的十二烷基三丁基溴化鏻(DDTB)插入層狀磷酸鋯得到一種耐高溫且具有優良抗菌性能季鏻陽離子柱撐磷酸鋯(DDTB-ZrPs)。通過熱重分析(TGA)、紅外分析(FTIR)、X射線衍射法(XRD)和透射電鏡(TEM)對DDTB-ZrPs的結構進行了表征，并測定了DDTB-ZrPs的最低抑菌濃度。結果表明，季鏻鹽已經成功插入層狀α-鏻酸鋯的層間，DDTB-ZrPs的層間距隨著季鏻鹽含量的增加而增加。DDTB-ZrP-1(DDTB含量為5.61wt%)的熱穩定性最好，有機物失重5%時溫度可達320℃，最大熱分解率溫度達384℃。DDTB-ZrP-6(DDTB含量為26.46wt%)顯示出良好的長效抗菌活性，對大腸桿菌和金黃色葡萄球菌的最低抑菌濃度分別為80和15 mg·L-1。進一步的研究表明，隨著DDTB含量的增加，DDTB-ZrPs的熱穩定性降低而抗菌活性增強。

α-鏻酸鋯；十二烷基三丁基溴化鏻；熱穩定性；抗菌活性

O614.41+2；O613.62

A

1001-4861(2011)05-0977-07

2010-09-14。收修改稿日期：2010-12-22。

國家自然科學基金(No.20871058)資助項目。。

＊通訊聯系人。E-mail：tanshaozao@163.com